The LED Based Solar Home
Lighting System is a portable lighting device suitable for
indoor lighting. In consists of a lamp, battery, solar charge
controller and electronics and a SPV module
LED Based Solar Home Lighting System is a device that operates
using the light energy available from the sun to provide
lighting during nighttime.
The LED Based Solar Home Lighting System can be used to have a
sufficient home light in the rural areas where electricity is
not available. It is powered through a Solar Photovoltaic
Module (SPV). These modules are manufactured to comply with
stringent quality standards and are capable of withstanding
the toughest environment conditions over a long service life.
- Latest Technology
- Easy installation and
- Long life span
- Energy efficient
||< 3 W
Depending on what the customer has ordered, ensure the
following items have been delivered:
Lantern : 01 No.
SPV Module : 01 No.
Accessories : 01 Set
Remove the Home
Lighting Lamp from the carton. Read & retain installation &
Maintenance Guide. Inspect for signs of any damages. If any
damages are observed, notify the dealer name and return the
unit to the factory immediately. If there are no obvious signs
of damage, read safety instructions and proceed with
Do not use
this apparatus near water and avoid contact of home light
with rain, snow, or liquids of any type.
with dry cloth.
accordance with the instructions given below.
install near any heat sources such as radiators, stoves or
other apparatus that produce heat.
Use only maintenance free battery.
Do not open
home light yourself. Take it to an authorized service
center, when service or repair is needed.
Fix the SPV
module to the mounting stand with inclination angle to the
sunlight in a suitable location, which must be in contact
with direct sunlight and away from trees and other types of
cable properly from SPV module to the SCC and terminate the
cable in proper direction at SPV connectors.
cable properly from lamp to the SCC and terminate the cable
in proper direction at lamp connectors.
green LED should glow as and when the cable is inserted
during daytime when sunlight is available.
Home Light must be left to charged for 2 sunny days for best
System is ready for operation.
To check the
Lamp Operation, remove the SPV input and switch ON the Home
Light. Observe the light output and restore the SPV input
and Home Light switch.
solar Panel clean from Dust and Bird droppings.
||Do not hammer
while fixing the SPV Module connections.
|Keep the Lamp
cover clean to get maximum light out put.
||Do not keep
Lantern near flame and water.
connections should be firmly tightened at SPV module.
in reverse polarities while replacing battery.
Clean the solar
panel regularly with a damp towel to ensure optimal
performance of the SPV Module. Donít use any type of solvent
for cleaning and be careful not to put too much pressure on
the panel during the cleaning process. To extend the life of
your Home Lighting System, it is recommended that solar panel
is stored indoors during the winter months or any other
extreme weather conditions.
- Keep the SPV Module free of
Dust and bird dropping etc, by wiping it with clean damp/dry
- Keep the Lamp cover clean to
get maximum light out put.
1. Home Light not switching
- Check battery low (Red LED)
indication, if Red LED is ON, then battery needs charging.
2. Battery not charging
(Green LED not glowing):
- Check for loose contact in
the SPV module to Lantern cable.
- Check the SPV Module output
voltage. If it is not sufficient check any shadows /
physical obstructions, which are blocking sunlight falling
on the SPV Module. If still problem exists replace the SPV
3. Battery discharging
Replace the battery as
the SPV Module.
of SCC and battery carefully by unscrewing three screws at
battery clamp and disconnect the battery by removing lugs.
remove the Battery from the casing.
Place the new
Battery in the casing, and observe the polarity while
reconnecting the lugs. (Red for +VE and Black for ĖVE).
If none of
them works call nearest service center/factory.
any solar product for an extended period of time, be sure to
remove the batteries.
solar product without regular recharge or removal could
cause permanent damage to the rechargeable batteries